NTSB CAROL · Event
Event SEA07LA046
Aircraft involved
Probable cause & findings
The pilot's failure to maintain control of the airplane during takeoff. A contributing factor to the accident was the improper takeoff configuration of the airplane.
Factual narrative
HISTORY OF FLIGHT
On January 11, 2007, at 1211 Pacific standard time, a Cessna TR182, N5443S, collided with runway 23 shortly after takeoff from Montgomery Field Airport, San Diego, California. The pilot was operating the airplane under the provisions of 14 CFR Part 91 as a personal flight. The commercial pilot, the sole occupant, sustained serious injuries. The airplane was substantially damaged. Visual meteorological conditions prevailed and an instrument flight rules flight plan was in effect. The pilot was destined for McClellan- Palomar Airport, Carlsbad, California. According to a witness, the airplane was departing runway 23. The takeoff roll and initial climb appeared normal. When the airplane reached about 100 feet above ground level, the nose pitched down and remained in this attitude until it impacted the ground. The main wreckage came to rest approximately 700 feet from the end of runway 23 and just off its right side. According to line personnel based at Montgomery Field, the pilot requested that his battery be recharged. They used a ground vehicle and successfully recharged the airplane's battery using the 12-volt receptacle on the airplane. The pilot then taxied the airplane to the active runway and departed. A representative from Cessna Aircraft Company responded to Montgomery Field and examined the airplane in a hangar with the Federal Aviation Administration accident coordinator present. The right flap appeared extended 40 degrees. The left flap appeared extended 10 degrees. The trim tab was measured at 10 degrees tab up. Photographs obtained from initial responders showed these approximate settings at the accident site.
PERSONNEL INFORMATION
The 79-year old pilot held a commercial pilot certificate and was certified to fly single and multi engine airplanes, as well as fly in instrument conditions. His last medical, a third class, was issued on January 5, 2006. It had no limitations or waivers. A review of the pilot's flight logbook showed that he had a total flight time of 2,807 hours. He had flown 13 hours in the past 90 days, 2 hours in the last 30 days, and 1 hour in the 24 hours preceding the accident. The pilot's son was interviewed by the National Transportation Safety Board investigator. His father was unable to be interviewed regarding the accident, and could not recall the events leading up to the accident. The pilot's son further stated that medical personnel did not find any evidence of an incapacitating medical event that may have initiated the accident sequence.
AIRCRAFT INFORMATION
The last annual inspection was completed on the airplane on April 11, 2006, at a tachometer time of 1,224.7 hours and a total airframe time of 3,275.6 hours. According to the airplane Pilot's Operating Handbook, the wing flaps should be set from 0 to 20 degrees, and the trim should be set at the takeoff position prior to departure. According to a representative from Cessna Aircraft Company, takeoff position is near 0 degrees elevator trim tab deflection.
TESTS AND RESEARCH
The airplane was examined on February 1, 2007, at Aircraft Recovery Service, Littlerock, California. The National Transportation Safety Board (NTSB) investigator and a Cessna representative were present. The control cables were traced throughout the wreckage and were continuous. The trim and autopilot switches were in the "OFF" position. The airplane was supplied power from its battery. When tested, the battery held 24.6 volts of electricity. The master and avionics switches were turned to the "ON" positions. The autopilot and trim switches (manufactured by S-Tec Corporation) were initially in the "OFF" position and did not power up when the system was supplied with power. Once the switches were placed in the "ON" positions, both systems activated. Preflight tests were conducted using the S-Tec operator's manual and produced corresponding activation to the autopilot and trim units. The Aero Trim system installation was examined in the left wing. The unit contained a servo, positioned in the aileron that connected to a power connector located in the wing. The plug that ran from the servo to the wing connect point was loose within the structure. The plug was visible, and in a position between the aileron control surface and wing structure. With the plug in this position, the ailerons could not be moved and were locked into place. When investigators examined the connect point in the wing, they noted that the plug end was capped off with a rubber fitting, and the wire was clamped so that it could not extend outside of the wing structure. The electrical lead on the servo side of the system within the aileron was found loose and there was no evidence of the wire having been secured. The flap system was powered using the airplane battery. At the flap selector, the handle indicated 10 degrees of flaps. Investigators noted that the instrument panel and flap actuation unit were bent aft and upward into the cabin area, approximately 20 degrees from the instrument panel's original design. Measurement of the flap actuator screw showed 6 inches of threads, which according to the Cessna representative, was consistent with a flap extension of 40 degrees. With power applied, there was no movement of the flap actuator. When investigators moved the flap selector from 0 degrees to 10 degrees, the cam moved from the UP microswitch to the DOWN microswitch. Due to the lack of tension on the flap follow up cable as a result of the accident sequence, investigators manually actuated both microswitches and they responded appropriately. The cables were continuous from the flap selector outboard to the flaps. Follow up cable tension prior to the accident could not be ascertained. According to the Cessna representative, the elevator trim tab measurement of approximately 10 degrees tab up equated to a nose down attitude.
ADDITIONAL INFORMATION
The wreckage was released to the owner's representative on April 17, 2007. No parts or pieces were retained by the NTSB. The airplane impacted the runway in a nose-down attitude during the takeoff initial climb out. The 79-year old pilot was departing on a short flight to his home airport when the accident occurred. According to a witness, the airplane climbed to 100 feet and suddenly pitched nose-down. The airplane continued in this attitude until ground impact. Post accident examination of the airplane control systems did not reveal any operational anomalies. Investigators noted that the trim tab was set 10 degrees nose down and the flaps were extended to 40 degrees. Both of these control positions are inconsistent with normal takeoff settings as specified by the airplane manufacturer. Source: NTSB Aviation Accident Database (Pre-2008 Archive) Retrieved: 2026-02-12
Verbatim from NTSB's published report. Source file
NTSB_2007_SEA07LA046.txt.
Findings + structured fields enriched from FAA avall.mdb.
Full investigation docket on
data.ntsb.gov ↗.
Beyond the agency record
Search this event elsewhere.
Pre-filled searches into the sources where news + community discussion of aviation events lives. External sources are reported, not agency. Treat them as signal that something happened, not as fact about what happened.
Entity-clustered aviation events in the press — last 24 hr + 30-day archive.
Official agency record + docket.
Investigative docket: factual reports, photos, transcripts.
Long-running aviation incident database (Flight Safety Foundation).
Community NTSB synthesis blog — often has photos and witness reports.
Gold-standard aviation incident blog.
Aviation industry news search.
GA pilot forum — informed but rumor-prone.
GA pilot subreddit search.
Tail-number page — flight history (free tier limited).
AOPA Air Safety Institute search.
Mainstream press coverage. Recent events only.
Privacy-preserving news search.
External links open in a new tab. We don't ingest their content; we deep-link search queries.
Related research
What the literature says.
Academic papers and agency reports matching this event's aircraft type or causal vocabulary (stall, autopilot). Sourced from NASA NTRS, NTSB Safety Studies, FAA CAMI, AOPA Air Safety Institute, Embry-Riddle Scholarly Commons, arXiv, and the Semantic Scholar academic graph.
- NASA NTRS 2026 · Conference Paper
Computational Analysis of Steady State Aerodynamics of Transonic Truss-Braced Wing Configuration in Deep Stall
This study presents a computational investigation of steady state aerodynamics of the Subsonic Ultra-Green Aircraft Research (SUGAR) Transonic Truss-Braced Wing (TTBW) configuration over a wide range …
- arXiv 2025 · arXiv preprint
ROSflight 2.0: Lean ROS 2-Based Autopilot for Unmanned Aerial Vehicles
ROSflight is a lean, open-source autopilot ecosystem for unmanned aerial vehicles (UAVs). Designed by researchers for researchers, it is built to lower the barrier to entry to UAV research and acceler…
- arXiv 2025 · arXiv preprint
ROSplane 2.0: A Fixed-Wing Autopilot for Research
Unmanned aerial vehicle (UAV) research requires the integration of cutting-edge technology into existing autopilot frameworks.
- arXiv 2024 · arXiv preprint
A Data-Driven Autopilot for Fixed-Wing Aircraft Based on Model Predictive Control
Autopilots for fixed-wing aircraft are typically designed based on linearized aerodynamic models consisting of stability and control derivatives obtained from wind-tunnel testing.
- arXiv 2023 · arXiv preprint
Automating Bird Diverter Installation through Multi-Aerial Robots and Signal Temporal Logic Specifications
This paper tackles the task assignment and trajectory generation problem for bird diverter installation using a fleet of multi-rotors.
- arXiv 2023 · arXiv preprint
Variation of Critical Crystallization Pressure for the Formation of Square Ice in Graphene Nanocapillaries
Two-dimensional square ice in graphene nanocapillaries at room temperature is a fascinating phenomenon and has been confirmed experimentally.
Browse the full corpus — academia portal ↗