NTSB CAROL · Event
Event BFO93FA153
Aircraft involved
Probable cause & findings
CORROSION IN THE FUEL CONTROL UNIT, WHICH RESULTED IN FUEL STARVATION AND LOSS OF ENGINE POWER. RELATED FACTORS WERE: INADEQUATE MAINTENANCE, AND THE LACK OF SUITABLE TERRAIN FOR AN EMERGENCY LANDING.
Factual narrative
HISTORY OF FLIGHT
On Friday, September 3, 1993, at 1241 eastern daylight time, N7666P, a Mooney M20J, owned by Brian Poole of Arnold, Maryland, and piloted by Michael J Duncan of Fort Washington, Maryland, lost engine power and collided with a tree while on initial climb during a power-off forced landing 1/2 mile from Freeway Airport, Mitchellville, Maryland. Visual meteorological conditions prevailed and a flight plan was not filed. The certificated flight instructor was seriously injured while the passenger, a mechanic was not injured. The airplane was substantially damaged. The check flight was conducted under 14 CFR 91. According to the pilot, he had completed his pretakeoff check and run-up successfully. He stated that the magneto drop on the run-up check was not greater than 100 rpm. He stated that the takeoff was normal, all the engine instruments were in the green range, and the airplane was accelerated to climb speed. He stated that it was windy that day, and there was some turbulence during the initial climb; however, at about 400 feet above the ground the engine lost power. He stated that, "it was as if someone had turned off the magnetos." He stated that he tried to restart the engine which included pumping the throttle, but he was unsuccessful. The airplane impacted in a wooded area separating a 5 foot section of the right wing. According to the FAA, this was the third flight after its maintenance to determine the reason for the prior two partial power losses. A witness who was at the departure end of runway 18 stated that when the airplane passed overhead, it sounded normal. The accident occurred during the hours of daylight, at 38 degrees 56.42 minutes North and 76 degrees 46.31 minutes West.
PERSONNEL INFORMATION
The pilot held a flight instructor certificate with single and multiengine land ratings. He reported over 2400 hours of total flight time including 150 hours in type.
AIRCRAFT INFORMATION
The 1988 year model Mooney M20J airplane, serial no. 24-1673 was equipped with a Lycoming IO-360-A3B6D, serial no. L24812-51A. According to the engine log book, the airplane had accumulated over 315 hours of total flight time including 34 hours since the last annual inspection that was completed on March 1, 1993.
METEOROLOGICAL INFORMATION
The 1255 surface weather observation for Andrews Airforce Base Airport, about 10 miles south of the accident site was as follows: Sky condition, 3000 feet scattered; visibility, 7 miles; temperature, 93 degrees (F); dew point, 69 degrees (F); wind condition, 220 degrees at 16 knots; and altimeter, 29.99 inches.
WRECKAGE AND IMPACT INFORMATION
The airplane collided with a tree separating a five foot section of the right wing. Examination of the accident site revealed the wreckage was confined within the dimensions of the airplane. The airplane was oriented on a 170 degree magnetic bearing. The airplane remained intact except the right aileron that separated with the 5 foot section of right wing. This section separated during the impact sequence and was located about 5 feet from the main wreckage. Both wings remained intact and contained a total of about 60 gallons. The empennage was intact. Flight control cable continuity was established to the left aileron in the left wing; however, control continuity was not established to the right aileron as it had separated during the impact sequence. Continuity was also established to the rudder and elevator. The landing gear and flaps were found in the retracted position. Examination of the engine revealed it remained intact. The engine was removed to Alphin Aircraft in Hagerstown, Maryland, on September 14, 1993 where an engine test run was completed under the supervision of the NTSB. Visual inspection of the engine did not disclose evidence of engine damage. The airplane's ram air to the fuel servo was replaced with an air filter 31 hours prior to the accident. Examination of the filter and the induction system revealed metal chips, dirt and a twig about one and one half inches long in front of the fuel servo. The air induction was intact. The propeller was bent during the impact sequence so a substitute propeller was used. The engine started after two attempts, and a manifold pressure of 26 inches and 2675 rpm was attained with the throttle set to the full forward position. The magnetos was selected to left, right and both positions, and no evidence of malfunction was noted. After the engine run, the fuel servo was removed for further examination. Visual examination of the fuel servo inlet screens revealed evidence of rust and corrosion on the spring, the threads of screen retaining plug and the opposite end of the spring around the "O" ring (see photos). The fuel servo was sent to Precision Air Incorporated in Miami, Florida, on September 30, 1993 for further examination under the supervision of the FAA. The examination disclosed evidence of corrosion and water in the diaphragm assembly. Details of the fuel servo examination is attached to this report.
ADDITIONAL INFORMATION
The wreckage was released to the owner's insurance representative on September 27, 1993. THE PILOT REPORTED THAT HE HAD COMPLETED HIS PRETAKEOFF CHECK AND RUN-UP, SUCCESSFULLY. HE STATED THAT DURING THE INITIAL CLIMB, AT ABOUT 400 FEET ABOVE THE GROUND, THE ENGINE LOST POWER. HE TRIED TO RESTART THE ENGINE, BUT WAS UNABLE. THE AIRPLANE IMPACTED IN A WOODED AREA ABOUT 1/2 MILE NORTH OF THE AIRPORT. THIS WAS THE SECOND FLIGHT WHILE IN MAINTENANCE TO DETERMINE TWO PRIOR PARTIAL POWER LOSSES DURING INITIAL CLIMB. THE AIRPLANE WAS REMOVED TO A HANGAR WHERE AN ENGINE RUN WAS ACCOMPLISHED AFTER A SUBSTITUTE PROPELLER WAS INSTALLED. THE ENGINE ATTAINED OVER 2675 RPM AND 26 INCHES OF MANIFOLD PRESSURE. EXAMINATION OF THE FUEL SERVO INLET SCREENS REVEALED EVIDENCE OF RUST AND CONTAMINATION. FURTHER TESTING OF THE SERVO INDICATED WATER AND CORROSION IN THE DIAPHRAGM ASSEMBLY. Source: NTSB Aviation Accident Database (Pre-2008 Archive) Retrieved: 2026-02-12
Verbatim from NTSB's published report. Source file
NTSB_1993_BFO93FA153.txt.
Findings + structured fields enriched from FAA avall.mdb.
Full investigation docket on
data.ntsb.gov ↗.
Beyond the agency record
Search this event elsewhere.
Pre-filled searches into the sources where news + community discussion of aviation events lives. External sources are reported, not agency. Treat them as signal that something happened, not as fact about what happened.
Entity-clustered aviation events in the press — last 24 hr + 30-day archive.
Official agency record + docket.
Investigative docket: factual reports, photos, transcripts.
Long-running aviation incident database (Flight Safety Foundation).
Community NTSB synthesis blog — often has photos and witness reports.
Gold-standard aviation incident blog.
Aviation industry news search.
GA pilot forum — informed but rumor-prone.
GA pilot subreddit search.
Tail-number page — flight history (free tier limited).
AOPA Air Safety Institute search.
Mainstream press coverage. Recent events only.
Privacy-preserving news search.
External links open in a new tab. We don't ingest their content; we deep-link search queries.
Related research
What the literature says.
Academic papers and agency reports matching this event's aircraft type or causal vocabulary (stall, fuel starvation, turbulence, maintenance). Sourced from NASA NTRS, NTSB Safety Studies, FAA CAMI, AOPA Air Safety Institute, Embry-Riddle Scholarly Commons, arXiv, and the Semantic Scholar academic graph.
- Embry-Riddle Scholarly Commons 2025 · Journal article (JAAER)
Political Turbulence and Aviation Safety: A Cross-National Analysis of Political Stability's Effects on Aviation Accidents
To what extent does political stability affect aviation safety? This research aims to link domestic political conditions and public safety through the consideration of aviation accident frequency.
- Embry-Riddle Scholarly Commons 2023 · Conference paper
The Value of Strong Partnerships to Build a Successful Aviation Maintenance Career Pathway Program for Transitioning Military Service Members
The aerospace industry is competing with other industries for a qualified workforce, and many of those competing industries are investing heavily in creating workforce development pipelines.
- Embry-Riddle Scholarly Commons 2021 · Journal article (IJAAA)
Comparative Study on the Prediction of Aerodynamic Characteristics of Mini - Unmanned Aerial Vehicle with Turbulence Models
When dealing with CFD simulations the turbulent nature is seen on most of the engineering flows and these flows need to be solved.
- arXiv 2020 · arXiv preprint
Numerical Simulation of Iced Wing Using Separating Shear Layer Fixed Turbulence Models
Aerodynamic prediction of glaze ice accretion on airfoils and wing is studied using the Reynolds-averaged Navier-Stokes method.
- NASA NTRS 2019 · Conference Paper
Prediction of stall and post-stall behavior of airfoils at low and high Reynolds numbers
An interactive boundary-layer method, together with the e(super n)-approach to the calculation of transition, has been used to predict the stall and post-stall behavior of airfoils at low and high Rey…
- Embry-Riddle Scholarly Commons 2026 · Journal article (IJAAA)
From Reactive to Predictive: A hybrid Trust-Mediated Adoption Framework for Data-Driven Maintenance in Distributed-Authority Aviation Environments
Modern aviation maintenance operates within increasingly data-intensive technological environments, yet the operational integration of predictive maintenance into routine decision-making remains incon…
Browse the full corpus — academia portal ↗